Product ID:EXTINGUISHER,FIRE,VAPORIZING LIQUID
MSDS Date:07/12/1989
FSC:4210
NIIN:01-042-0268
MSDS Number: BGXKQ

MFR UNKNOWN/DEFENSE CONSTRUCTION S.CTR PROCURED

COLUMBUS, OH 43216-5000
US

Info Phone: 614-238-3131

Preparer: DGSC-SLM/DOD HMIS

Cage: JO772

MFR UNKNOWN/DEFENSE INDUSTRIAL SUPPLY CTR PROCURED

3990 PHILADELPHIA, PA 19111-5096 US

Telephone: 215-697-2000

Cage: JO772

BROMOCHLORODIFLUOROMETHANE (AS EXTINGUISHING AGENT)

CAS: 353-59-3

RTECS: PA5270000

OSHA PEL NONE ESTABLISHED

ACGIH TLV: NONE ESTABLISHED

NITROGEN

CAS: 7727-37-9

RTECS: QW9700000

ACGIH TLV: ASPHYXIANT; 9192

LD50 LC50 Mixture:LC50(RAT): 20 PPH/15M
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:ASPHYXIANT, CNS' & PULMONARY
EFFECTS. SKIN IRRITANT. CHRONIC:NONE KNOWN.
Effects of Overexposure:INHAL:DIZZINESS,DISORIENTATION, IMPAIRED
COORDINATION, NARCOSIS, NAUSEA OR VOMITING, LIGHT-HEADEDNESS,
GIDDINESS, BREATH SHORTNESS. CARDIAC ARRHYTHMIA W/ UNCONSCIOUSNESS
OR EVEN DEATH IN HI-CONC W/LON G EXPOSURES; SKIN/EYES: CONTACT W/
LIQUID CAN CAUSE FROSTBITE, OR SKIN IRRITATION.
Medical Cond Aggravated by Exposure:CARDIAC PROBLEMS. (PRODUCT IS AN
ASPHYXIANT & CAN INDUCE CARDIAC MUSCLE SENSITIZATION IF CIRCULATING
EPINEPHRINE-LIKE COMPOUNDS).

First Aid:INHAL:REMOVE TO FRESH AIR-GET MED ATTN & GIVE O*2/CPR AS
REQUIRED FOR SITUATION @ HAND; DONOT GIVE EPINEPHRINE OR SIMILIAR
DRUGS AS CATECOLAMINES INCREASE RISK OF ELICITING CARDIAC
DYSRYTHMIAS. EYES/S KIN:FLUSH W/WATER-TREAT FOR FROSTBITE W/MEDICAL
ATTN; INGEST:NOT LIKELY TO OCCUR.

Flash Point:NONE
Extinguishing Media:MATERIAL IS A FIRE EXTINGUISHANT & IS
NON-FLAMMABLE. USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE SCBA' WHEN FIGHTING FIRES WHERE CHEMICALS
ARE INVOLVED. SCBA MAY BE NEEDED IF HALON-1211 CONTAINER RUPTURES
OR RELEASES MATERIAL IN HEAT OF FIRE.
Unusual Fire/Explosion Hazard:IN HEAT OF FIRE, HALON-1211 CONTAINERS
EXPOSED TO INTENSE HEAT OF FIRE MAY RUPTURE & MATERIAL
DECOMPOSITION MAY OCCUR.

Spill Release Procedures:EVACUATE AREA OF UNNEEDED PERSONNEL, VENTILATE
AREA ESPECIALLY LOW PLACES WHERE HEAVY VAPORS MIGHT COLLECT. COOL
OR REMOVE HOT METAL SURFACES OR SOURCES OF NON-EXTINGUISHED FLAMES.

Handling and Storage Precautions:STORE & HANDLE AS A LIQUIFIED
COMPRESSED GAS IN DOT' APPROVED PRESSURE VESSELS AWAY FROM
HI-TEMPERATURES.
Other Precautions:AVOID UNNECESSARY EXPOSURE TO HALON 1211! ABOVE 4%(17
LBS/1000 CU FT AIR & > 1 MIN:DIZZINESS,IMPAIRED COORDINATION &
REDUCED MENTAL ALERTNESS);ABOVE 5% CONC (22 LBS/1000 CU FT OF
AIR),USE AIR-SUPPLIED RESPIRATORS.

Respiratory Protection:NOT NORMALLY NECESSARY IF PROPER ENGINEERING
CONTROLS ARE IN PLACE. IF PEL/TLV ARE EXCEEDED,USE POSITIVE
PRESSURE AIR-SUPPLIED RESPIRATOR. REVIEW 29CFR1910.134
INSTRUCTIONS/WARNINGS AS WELL AS NIOSH-R ESPIRATOR DECISON LOGIC
PUB87.108.
Ventilation:PROVIDE SUFFICIENT GENERAL/LOCAL EXHAUST VENTILATION IN
PATTERN/VOLUME TO CONTROL INHALATION EXPOSURES BELOW PEL/TLV.
Protective Gloves:LINED BUTYL OR AS REQUIRED FOR TASK.
Eye Protection:CHEMICAL SPLASH TYPE OR AS REQ FOR TASK.
Other Protective Equipment:AS REQUIRED TO MINIMIZE EXPOSURE & MAXIMIZE
INDIVIDUAL PROTECTION.
Work Hygienic Practices:OBSERVE PROCEDURES SET FORTH BY SAFETY/IH
PERSONNEL FOR USE OF THIS MATERIAL FOR TASKS AT HAND.
Supplemental Safety and Health
SMALL CONC(5%) OF HALON EXTINGUISH FLAMES BY CHEMICALLY INTERRUPTING
COMBUSTION-NOT BY REPLACING O*2. HOWEVER, VAPORIZATION OF EXCESSIVE
AMTS. CAN DEPLETE OR REPLACE O*2 NEEDED FOR BREATHING; GENERIC
MSDS' ON NSN IDENTIFIED BY "DCSC". UPON RECEIPT OF A MFR'S MSDS
UNDER THIS NSN, THE GENERIC WILL BE REMV.

HCC:G3
Boiling Pt:B.P. Text:26F/-3.3C
Melt/Freeze Pt:M.P/F.P Text:-257F/-161C
Vapor Pres:1897@70F
Vapor Density:5.7
Spec Gravity:1.83
Evaporation Rate & Reference:RAPID; REFERENCE UNK
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUIFIED GAS(SEE BOILING PT) W/SLIGHT
ETHEREAL ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
ACTIVE METALS (EG. ALKALINE EARTH & ALKALINE EARTH METALS, POWDERED AL,
ZN, BE, ETC.) & METAL HYDRIDES.
Stability Condition to Avoid:FLAMES OR HOT SURFACES >900F CAN CAUSE
DECOMPOSITION OF MATERIAL.
Hazardous Decomposition Products:AT HI-TEMPS(>900F): HF, HBR, FREE BR,
POSSIBLE CARBONYL HALIDES, & OXIDES OF BROMINE, FLUORINE, OR
CARBON.

Waste Disposal Methods:COMPLY W/ ALL FEDERAL,STATE & LOCAL REGULATIONS.
RECLAIM MATERIAL IN A SUITABLE VAPOR RECOVERY SYSTEM/EQUIPMENT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.